Author |
Message |
Bbviper
|
Posted: Thu Jun 19, 2008 11:15 pm |
|
Joined: Wed Aug 13, 2003 5:03 pm Posts: 315 Location: Bonduel , WI
|
Can anyone show me any information on how to remove the Power steering pump. Has anyone done this? How hard is it ? Tips or tricks welcome. Tim
_________________ Is it true that cannibals won't eat clowns because they taste funny?
What happens if you get scared half to death twice?
|
|
Top |
|
|
veerfour05
|
Posted: Fri Jun 20, 2008 3:16 am |
|
Joined: Thu May 24, 2007 1:40 pm Posts: 123 Location: Shakopee MN
|
|
Top |
|
|
G-ELL
|
Posted: Thu Jun 26, 2008 3:53 pm |
|
Joined: Wed Aug 13, 2003 1:18 am Posts: 3153 Location: Lehigh Valley, PA
|
Piece of cake if you have hands like me..
It's only held to the motor by 1 14mm nut, and 1 14mm bolt. The only other thing you need to disconnect is the idle ground wire, low, and high pressure steering lines. Think it's a 12mm nut for the high pressure line.
Then there's the belt of course. 2 14mm bolts will loosen that. Just leave the belt dangle in the engine bay, don't take it all the way out.
_________________ 06 Blue EVO 9
|
|
Top |
|
|
440 4x4
|
Posted: Thu Jun 26, 2008 4:52 pm |
|
Joined: Mon Dec 01, 2003 9:56 am Posts: 637 Location: Milwaukee
|
G-ELL wrote: Piece of cake if you have hands like me..
It's only held to the motor by 1 14mm nut, and 1 14mm bolt. The only other thing you need to disconnect is the idle ground wire, low, and high pressure steering lines. Think it's a 12mm nut for the high pressure line.
Then there's the belt of course. 2 14mm bolts will loosen that. Just leave the belt dangle in the engine bay, don't take it all the way out. What kind of hands do you have????????? 17mm nut for high pressure line.
|
|
Top |
|
|
unclebenny
|
Posted: Thu Jun 26, 2008 5:17 pm |
|
Joined: Wed Oct 08, 2003 3:27 am Posts: 934 Location: Oconomowoc WI
|
440 4x4 wrote: What kind of hands do you have????????? Greg has what are commonly referred to as chinese fingers. They are widely used in the aquisition of soft tacos and hard to reach bolts.
_________________
|
|
Top |
|
|
440 4x4
|
Posted: Thu Jun 26, 2008 9:50 pm |
|
Joined: Mon Dec 01, 2003 9:56 am Posts: 637 Location: Milwaukee
|
Thank you for clearing that up
|
|
Top |
|
|
veerfour05
|
Posted: Fri Jun 27, 2008 5:16 am |
|
Joined: Thu May 24, 2007 1:40 pm Posts: 123 Location: Shakopee MN
|
When you disconnect the lines take a 3/8" extension and shove it into the line while it's off the pump. It will keep a lot of the fluid from leaking out and make the bleeding process easier.
|
|
Top |
|
|
G-ELL
|
Posted: Fri Jun 27, 2008 5:46 pm |
|
Joined: Wed Aug 13, 2003 1:18 am Posts: 3153 Location: Lehigh Valley, PA
|
unclebenny wrote: 440 4x4 wrote: What kind of hands do you have????????? Greg has what are commonly referred to as chinese fingers. They are widely used in the aquisition of soft tacos and hard to reach bolts. Also good for reaching the spot of the Gs which is a favorite amongst women.
_________________ 06 Blue EVO 9
|
|
Top |
|
|
slimsunny34
|
Posted: Sat Jun 28, 2008 9:02 am |
|
Joined: Tue May 15, 2007 8:33 pm Posts: 440 Location: Madison, WI
|
G-ELL wrote: Also good for reaching the spot of the Gs which is a favorite amongst women. TMI!
_________________ www.rockauto.com
The tree of liberty must be refreshed from time to time, with the blood of patriots and tyrants.
|
|
Top |
|
|
Bbviper
|
Posted: Mon Jun 30, 2008 2:47 pm |
|
Joined: Wed Aug 13, 2003 5:03 pm Posts: 315 Location: Bonduel , WI
|
Sweet Guys ! It sounds so easy I bet I can do it with my sunglasses on and one hand tied behind my back. Well maybee that is a bit over the top BUT , the girl next door could be in that just TO SMALL bikini I bet it would help in some way !!!!!!!! BOOYAHH I think I have had to much sun.
_________________ Is it true that cannibals won't eat clowns because they taste funny?
What happens if you get scared half to death twice?
|
|
Top |
|
|